Product ID:BLACK TRAFFIC LINE PAINT, 1073
MSDS Date:12/01/1991
FSC:8010
NIIN:00N049276
MSDS Number: BVCRZ

FARWEST PAINT MFG CO

4522 S 133RD ST
TUKWILA, WA 98168
US

Emergency Phone: 206-941-1619

Info Phone: 206-244-8844

Cage: 6F266

FARWEST PAINT MANUFACTURING CO

TUKWILA, WA 98168 US

Telephone: 206-244-8844

Cage: 6F266

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 4.9%

OSHA PEL 200 PPM;150 STEL

ACGIH TLV: 50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LIGROINE; (MINERAL SPIRITS 350)

CAS: 8032-32-4

RTECS: OI6180000

Fraction By Weight: 2.5%

OSHA PEL 300 PPM;400 STEL

ACGIH TLV: 300 PPM

SOLVENT NAPHTHA (PETROLEUM), LIGHT ALIPHATIC; (MINERAL

CAS: 64742-89-8

Fraction By Weight: 21.6%

OSHA PEL 500 PPM

ACGIH TLV: 500 PPM

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SKIN: THIS MATERIAL MAY CAUSE
IRRITATION, SENSITIZATION, OR DEFATTING OF SKIN UPON PROLONGED OR
REPEATED CONTACT. INHAL: EXCESSIVE EXPOSURE TO VAPORS OR SPRAY
MISTS CAN RESULT IN HEADACHE, DIZZINESS, NAUSEA AND LOSS OF
CONSCIOUSNESS. SOME REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED
OCCUP OVEREXP (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: TO SOLV W/PERMANENT BRAIN AND NERVOUS
SYSTEM DAMAGE. EYE: THIS MATERIAL MAY BE AN EYE IRRITANT. NOTE:
TOLUENE APPEARS ON THE NAVY LISTING OF OCCUP CHEM REPROD HAZS. SEEK
CONSULTATION FROM AP PROPRIATE HLTH PROFESSIONALS CONCERNINGLATEST
HAZ LIST INFORMATION AND SAFE HNDLG AND EXPOSURE INFORMATION .
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:SKIN: PROMPTLY WASH W/SOAP & WATER. REMOVE AND WASH ANY
CONTAM CLTHG BEFORE REUSE. EYE: FLUSH W/LRG QTYS OF WATER FOR AT
LEAST 15 MIN & SEEK MED ATTN. INGEST: DO NOT INDUCE VOMIT, KEEP
PERSON WARM, QU IET & GET MEDICAL ATTN. ASPIRATION OF MATERIAL INTO
LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL. INHAL:
REMOVE VICTIM TO FRESH AIR IMMED. IF RESP SYMPTOMS DEVELOP, SEEK
MED ATTN AT ONCE.

Flash Point Method:TCC
Flash Point:45.0F,7.2C
Lower Limits:0.7%
Extinguishing Media:FOAM, CO*2, DRY CHEM, WATER FOG. WATER MAY BE
UNSUITABLE AS AN EXTING MEDIUM, BUT HELPFUL IN KEEP ADJACENT CNTNRS
COOL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT (FP N ). EVACUATE AREA OF UNPROTECTED
PERSONNEL. WEAR PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:VAPORS MAY FORM AN EXPLOSIVE MIXTURE IN
AIR & MAY BE IGNITED BY SPARKS, PILOT LIGHTS, ETC. CLOSED CNTNRS
MAY RUPTURE WHEN EXPOSED TO EXTREME HEAT.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT. VENT AREA. ABSORB
SPILL W/AN ABSORB MATL SUCH AS SAWDUST, VERMICULITE/SAND & PLACE
MATL INTO A CLSD CNTNR. IF LRG SPILL, DIKE AREA TO PVNT THIS MATL
FROM ENTERING WATER SY STEMS/SEWERS. WEAR PROT EQUIP DURING
CLEANUP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:AVOID PROLONGED OR REPEATED INHAL OF
HEATED VAPS OR SPRAY MISTS. KEEP AWAY FROM HEAT OR OPEN FLAME. THIS
MATL MAY CAUSE SENSITIZATION.
Other Precautions:DO NOT GET IN EYES, ON SKIN OR CLOTHING. DO NOT ALLOW
CONTAMINATED CLOTHING TO CONTACT SKIN. DO NOT WELD ON FULL OR EMPTY
CNTNRS. KEEP CNTNRS CLSD, WHEN NOT IN USE, & PROPERLY LABELED.

Respiratory Protection:NIOSH/MSHA APPROVED CANISTER-TYPE RESP MUST BE
WORN TO PVNT THE INHAL OF VAPORS OR SPRAY MISTS WHEN THE TLV OR PEL
IS EXCEEDED.
Ventilation:GENERAL VENT IS REQUIRED DURING NORMAL USE. LOC VENT MAY BE
REQUIRED DURING CERTAIN OPERATIONS TO KEEP (SUPP DATA)
Protective Gloves:CHEM RESISTANT/NITRILE/NOEPRENE/RUBBER
Eye Protection:ANSI APPVD CHEM GOGG W/FCSHLD .
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER WHICH
MEET ANSI DESIGN CRITERIA SHOULD BE AVAILABLE .
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
WASTE DISP: RECORDKEEPING STANDARDS. DISPOSE IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL AGENCIES. GROUND HANDLING EQUIPMENT TO PVNT
SPARKS. VENT: EXPOSURE LEVEL BELOW THE LIMITS LISTED IN INGREDIENT
SECTION OF THIS MSDS.

Boiling Pt:B.P. Text:>203F,>95C
Vapor Pres:53 @ 20C
Vapor Density:HVR/AIR
Spec Gravity:1.43
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NIL
Appearance and Odor:BLACK LIQUID
Percent Volatiles by Volume:53

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDANTS, ACIDS, BASES AND EPOXY HARDENERS
UNDER UNCOTROLLED CONDITIONS.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAMES. IF PRODUCT
CONTAINS ALUMINUM, MOISTURE IN CLOSED CONTAINERS WILL GENERATE
HYDROGEN.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION CAN YIELD CARBON
MONOXIDE AND TOXIC VAPORS.

Waste Disposal Methods:IF DISCARDED, THIS MATL & CNTNRS SHOULD BE
TREATED AS HAZ WASTES BASED ON THE CHARAC OF IGNITABILITY AS
DEFINED UNDER FEDERAL RCRA REGS (40 CFR 261). DISP OF THIS MATL/ITS
CNTNR REQUIRES COMPLIANCE W/ APPLICABLE LABELING, PACKAGING, &
(SUPP DATA)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.